GTS PROJECTS’s DISSOLVED AIR FLOATATION SYSTEM FOR CARWASH EFFLUENT TREATMENT & RECYCLING SYSTEM

 



GTS PROJECTS’s DISSOLVED AIR   FLOATATION SYSTEM

FOR CARWASH EFFLUENT TREATMENT & RECYCLING SYSTEM

 

The perfect combination of UF membrane technology and DAF with efficient system design

 

OVERVIEW:

Floatation Dissolved Air (DAF) is the process of removing suspended solids, oils and other contaminants via the use of air bubble flotation. Air is dissolved into water, mixed with the waste stream and released from solution while in intimate contact with the contaminants. Air bubbles form, attach to the solids, increase their buoyancy and float the solids to the water's surface.

The dissolved air comes out of solution, producing millions of microscopic bubbles. These bubbles attach to the solids and float them to the surface where they are mechanically skimmed and removed from the tank. GTS PROJECTS’s Skid Mounted DAF cum UF System is designed to remove fats, oils & grease (FOG), suspended solids, hydrocarbon oils/emulsions and many other contaminants.

 

Benefits

 1. Cost is lower than any other system of comparable waste extraction performance.

2. The unit is typically delivered fully prefabricated.

3. Space requirements are minimal.

4. Capability to treat a wide variety of organic, inorganic solids and dissolved waste.

5. Low retention time from wastewater stream to effluent ejection.

6. Superior clarification of most waste streams.

7. Easy to clean and maintain.

8. Higher density sludge with low water content.

 

 

Ultra filtration (UF) is a continuous process for separating high molecular weight, colloidal or suspended solids from fluid streams. The key to the process is a thin, polymeric, semi-permeable membrane. Feed solution is pumped at low pressures and high flow rates across the surface of the membrane. Solutes whose sizes are greater than the pore size (0.1-micron) of the membrane and all suspended solids are retained and concentrated. Water, salts, and small molecular weight constituents pass through, or permeate, the membrane. Thus, the pore structure of the membrane acts as a molecular filter that does not become plugged because the retained components of the feed are rejected at the surface and do not penetrate the membrane.

 

Benefits

 1. Provides a verifiable physical barrier to turbidity, bacteria, Cryptosporidium and viruses    

 2. Water recycle yields Zero Liquid Discharge capabilities.

 3. High concentration and minimizes disposal costs.

 4. Low initial set up costs.

 5. Minimal pretreatment chemicals needed.

 

Thanks & Regards

G.Thirugnanam

GTS PROJECTS

18, Ambal Nagar,

Near V.G Rao Nagar,

Ganapathy, Coimbatore- 641006

Phone: +91 9843030427

Email: enviroindia@gmail.com, 

info@gtsprojects.in

Website: www.gtsprojects.in

Popular posts from this blog

GTS PROJECTS’s Retrofitted Emission Control System for DG Set (Diesel generator)

Image
   Why GTS PROJECTS’s Retrofitted Emission Control Equipment (Wet Scrubber System for DG Set) Required? “The Emission including Particulate matters due to operation of Generators set has also been identified as one of the sources of air pollution in Tamilnadu. There is a plan for a national level target of 30% reduction of PM 2.5 and PM10 concentration in the Ambient Air under the National Clear Air Program(NCAP). To Achieve the same TN Govt have taken an initiative to reduce the emissions of Generator sets used by the people in Tamilnadu. TN Govt have requested all the people who are using generators using 125kVA and above to fix Retrofit Equipment or a device to reduce the emissions from the Diesel Generator sets. GTS PROJECTS’s Retrofitted Emission Control System for DG Set GTS PROJECTS’s Retrofitted Emission Control System  is the device to remove emissions from the Diesel Generator engine exhaust flue gas. Retrofits can be very effective at reducing emissio...
Read more

GTS PROJECTS - FLASH MIXERS, AGITATORS, CLARI-FLOCULATORS, TUBE SETTLERS

Image
We GTS PROJECTS manufacture, supply, installation and commissioning of FLASH MIXER and AGITATOR iin varies sizes and capacity for Chemicals preparation and floculation/ coagulation in Water Treatment and Industrial Effluent treatment plants We GTS PROJECTS have successfully supplied and installed one of our product TUBE SETTLER MEDIA in CLARIFIER of WATER TREATMENT PLANT.. Thanks & Regards G.Thirugnanam GTS PROJECTS 18,Ambal Nagar, Near V.G Rao Nagar, Ganapathy, Coimbatore- 641006 Phone: 9843030427 Email: enviroindia@gmail.com, info@gtsprojects.in Website: www.gtsprojects.in/ brochures/ .
Read more

Wet Scrubber

Image
With the intent to effectively prevent the air pollution, GTS Projects India P Ltd manufacture and supply superior quality air pollution control systems. Precision designed, these systems are used in diverse industries all across the globe. Use of sophisticated technology and engineering expertise enables us to offer them as per the demands of our clients.SCRUBBER SYSTEMS  GTS PROJECTS INDIA P LTD offer a comprehensive range of WET SCRUBBER systems, which are designed by us using cutting edge technology. Available in standard as well as customized specifications, these systems meet the varied requirements of air handling applications in various industries like: Pharmaceutical Industries, Power Plants, Foundries, Chemical Industries. GTS Projects India P Ltd have fabricated and installed CHIMNEY/EXHAUST PIPING for process exhaust hot air We GTS PROJECTS have manufactured and  installed WET SCRUBBER SYSTEM (Air pollutio...
Read more